Product ID:ISOPROPANOL, ANHYDROUS
MSDS Date:04/17/1998
FSC:6810
NIIN:00-543-7915
Status Code:A
MSDS Number: CJHXC

Emergency Phone: 804-264-5183

Info Phone: 804-264-5183

Cage: 0YED2

Telephone: 264-5535

Cage: 0YED2

ISOPROPANOL, ANHYDROUS

CAS: 67-63-0

RTECS: NT8050000

OSHA PEL 980 MG/M3;400 PPM

ACGIH TLV: 983 MG/M3;400 PPM

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: EYE, SKIN, CNS,
RESPIRATORY AND GI TRACTS (HMIS). ACUTE - EYE CONTACT: LIQUID
CAUSES SLIGHT TO MODERATE IRRITATION WITH POTENTIAL FOR CORNEAL
INJURY. SKIN CONTACT: PROLONGED CONTACT MAY CAUSE DRYNESS AND
CRACKING. PROLONGED EXPOSURE OVER LARGE AREAS MAY RESULT IN
ABSORPTION OF HARMFUL AMOUNTS BY INFANTS. INHALATION: EXPOSURE TO
LOW CONCENTRATIONS MAY CAUSE NOSE AND THROAT IRRITATION . EXPOSURE
TO CONCENTRATIONS ABOVE TLV MAY CAUSE HEADACHE AND DROWSINESS.
SWALLOWING: SLIGHTLY TOXIC. INGESTION OF A LARGE QUANTITY MAY CAUSE
LOSS OF CONSCIOUSNESS, NAUSEA, VOMITING, STOMACH PAINS. CH HRONIC -
NO DATA TO SHOW ADVERSE EFFECTS
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYE IRRITATION WITH POTENTIAL FOR CORNEAL
INJURY, SKIN DRYNESS AND CRACKING, NOSE AND THROAT IRRITATION,
HEADACHE, DROWSINESS, LOSS OF CONSCIOUSNESS, NAUSEA, VOMITING,
STOMACH PAINS, CRAMPS

First Aid:N/P. WASH THOROUGHLY AFTER HANDLING ANY CHEMICAL MATERIAL.
CONSULT A PHYSICIAN IF EYE CONTACT OCCURS OR INGESTED (HMIS).

Flash Point Method:TCC
Flash Point:=11.7C, 53.F
63F TOC
Lower Limits:2.0 %
Upper Limits:12.7 % @200F
Extinguishing Media:APPLY ALCOHOL-TYPE OR GENERAL PURPOSE FOAMS USING
TECHNIQUES RECOMMENDED BY MANUFACTURER FOR LARGE FIRES. FOR SMALL
FIRES, USE CO2 OR DRY CHEMICAL AGENTS.
Fire Fighting Procedures:USE WATER SPRAY TO COOL CONTAINERS EXPOSED TO
FIRE. WATER SPRAY CAN DISPERSE VAPORS BUT REIGNITION MAY OCCUR. USE
SELF-CONTAINED BREATHING APPARATUS AND PROTECTIVE CLOTHING IN FIRE
EXPOSURE SITUATIONS .
Unusual Fire/Explosion Hazard:VAPORS FROM THIS PRODUCT MAY BE IGNITED
BY SPARKS OR OPEN FLAMES OR ELECTRICAL EQUIPMENT. VAPORS MAY SETTLE
IN LOW PLACES OR TRAVEL LONG DISTANCES TO A SOURCE OF IGNITION AND
THUS CAUSE EXPLOSIVE FLAS HBACK. THIS PRODUCT MAY CAUSE A FLOATING
FIRE HAZARD.

Handling and Storage Precautions:STORE IN A COOL, DRY, VENTILATED AREA
AWAY FROM HEAT, SPARKS AND OPEN FLAMES.
Other Precautions:CAUSES EYE IRRITATION. FOR INDUSTRIAL USE ONLY.
WARNING! FLAMMABLE. KEEP CONTAINER CLOSED UNTIL READY FOR USE. USE
WITH ADEQUATE VENTILATION.

Respiratory Protection:USE A NIOSH-APPROVED SELF-CONTAINED BREATHING
APPARATUS IN HIGH VAPOR CONCENTRATIONS.
Ventilation:USE LOCAL VENTILATION AT POINTS WHERE VAPORS ARE EXPECTED
TO BE PRESENT. USE GENERAL MECHANICAL ROOM VENTILATION AS REQUIRED.
Protective Gloves:RUBBER OR NEOPRENE OR PLASTIC
Eye Protection:CHEMICAL SAFETY GOGGLES
Other Protective Equipment:EYE WASH SYSTEM, BODY FLUSH
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH AFTER HANDLING AND BEFORE EATING,
DRINKING OR SMOKING.
Supplemental Safety and Health

HCC:F2
Boiling Pt:=82.3C, 180.1F
Melt/Freeze Pt:=-88.5C, -127.3F
Vapor Pres:33 @ 68F
Vapor Density:2.07
Spec Gravity:0.7864
Evaporation Rate & Reference:2.88 (BUTYL ACETATE = 1)
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID, CHARACTERISTIC ODOR
Percent Volatiles by Volume:100

Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL,
STATE, AND FEDERAL LAWS AND REGULATIONS (HMIS).

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.